View Full Version : Reusing sump washer
I've recently done an oil change on my car and have reused the sump washer...checked it today and it was leaking a bit/bolt was slightly loose...arse!
I've tightened it up as much as i can now but the book recommends 15nm or torque...will me tightening it as far as it'll go (as much as you can lying underneith) equate to that sort of pressure?
there is on rule ... never reuse sump washer allways by a new one ..
UNLESS YOUR A TIGHT ASS .. 10 DAM PENCE I TELL YOU 10 PENCE
!!!!!!!!!!!!! JEW !!!!!!!!!!!!!!!
also the sump is very thin and can not take overtighting hand tight only AND I DO NOT MEAN HE MAN TIGHT
is it an ally sump or a pressed steel jobbie?
or u could re-use it...but it needs heatin up to cherry red first...
the copper sump washers are 10p, the other ones with the rubber bit are about £1
Its a steel sump.
Anyway, I've tightened it up as far as possible and its remained tight for the 350mile trip today so thats good enough. If its damaged the thread then so be it - it'll be long sold before it need changed again so will be someone elses problem.
Laine_16v
19-03-2006, 19:22
lol i used mine again last oil change, its worked fine as far as i can see.
lol i used mine again last oil change, its worked fine as far as i can see.
dito!
any1 else re-used theres?
Garage re used mine once, leaked after about 3 months
FlamingMonkey
20-03-2006, 00:30
I re-used mine, cunting motorfactors gave me the wrong one, no problems, but I change the oil quite often though
Garage re used mine once, leaked after about 3 months
ill have to keep an eye on mine then....was it quite bad tom or just a drip here n there?
flippin heck, all over a 20p washer?! :roll: :D
flippin heck, all over a 20p washer?! :roll: :D
i just 4got 2 get 1 at the time so had 2 reuse.......checkd it 2day and it is leekin abit so wen and bought 1.....the robbin bastards charged nme £1.06 for it!
flippin heck, all over a 20p washer?! :roll: :D
:lol: YOUR NOT DAM WRONG ..
........................ TIGHT ASSES ..........................
:lol: :lol: :lol:
Garage re used mine once, leaked after about 3 months
ill have to keep an eye on mine then....was it quite bad tom or just a drip here n there?
just the odd drip
MatBrown
23-03-2006, 22:45
I've re-used a few.
Really ought to buy a bulk load!
Mat.
recon i should drain the oil and change the washer or just leave it? its only dripin here n there???
ive re used mine twice now!
just tighten it up properly and its fine. not too much that you will strip the thread tho!
sod it RE-USE the oil .. :lol:
sod it RE-USE the oil .. :lol:
thats my plan :P
got a filter from reno today and a sump washer and they give the sump washer to me for free..
wot a upgrade .. NEW WASHER yea
do gearbox plugs have copper washers too? can't remember their being one last time i took it off.
they do have washers not sure if its the copper type though
Andyvalver
28-03-2006, 00:08
:lol: Ive re-used mine before. Its only a washer ffs ive never had a problem :wink:
bepends whitch one the level test or the drain the level one does not it is nylon thumb swrew
Powered by vBulletin® Version 4.2.5 Copyright © 2024 vBulletin Solutions Inc. All rights reserved.